| Recall Date: |
JUL 17, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
CAPRICE |
| Units Affected: |
3593
Recall Details
|
Recall Date:
JUL 17, 2006
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Units Affected:
3593
Notes:
AJ MOTORSPORT
| Recall Date: |
OCT 29, 1991 |
| Component: |
LATCHES/LOCKS/LINKAGES:HOOD:LATCH |
| Model Affected: |
CAPRICE |
| Units Affected: |
224588
Recall Details
|
Recall Date:
OCT 29, 1991
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
SECONDARY HOOD LATCH ASSEMBLIES CAN CORRODE, CAUSING A HIGH LATCH RELEASE EFFORT AND POSSIBLY PREVENTING THE HOOD FROM LATCHING PROPERLY WHEN IT IS CLOSED.
Consequence:
IF THE SECONDARY HOOD LATCH IS NOT PROPERLY ENGAGED, ANDTHE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN AND CONTACT THEWINDSHIELD WHILE THE VEHICLE WAS IN MOTION, REDUCING THE FORWARD VISION AREA OFTHE DRIVER AND RESULTING IN A POSSIBLE VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
Remedy:
INSTALL A NEW SECONDARY HOOD LATCH ASSEMBLY.
Units Affected:
224588
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
MAY 11, 2009 |
| Component: |
EXTERIOR LIGHTING:HEADLIGHTS |
| Model Affected: |
CAPRICE |
| Units Affected: |
42540
Recall Details
|
Recall Date:
MAY 11, 2009
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Units Affected:
42540
Notes:
DOPE, INC.
| Recall Date: |
MAR 23, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
CAPRICE |
| Units Affected: |
61944
Recall Details
|
Recall Date:
MAR 23, 2006
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Units Affected:
61944
Notes:
PRO-A MOTORS, INC.
| Recall Date: |
JUN 24, 1992 |
| Component: |
WHEELS |
| Model Affected: |
CAPRICE |
| Units Affected: |
34717
Recall Details
|
Recall Date:
JUN 24, 1992
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
THE STEEL WHEELS EXHIBIT FATIGUE CRACKING AROUND THE CIRCUMFERENCE OF THE WHEEL LUG NUT MOUNTING SURFACE DUE TO WHEEL BENDING CAUSED BY FREQUENT MISUSE OF TIRE MOUNTING EQUIPMENT, LUG NUT OVERTORQUING, AND THE UNUSUAL OPERATING CONDITIONS EXPERIENCED BY POLICE VEHICLES.
Consequence:
THE CRACKING CAN CAUSE WHEEL FRACTURING AND SUBSEQUENTSEPARATION FROM THE AXLE, WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Remedy:
REPLACE THE DEFECTIVE WHEELS WITH REDESIGNED STEEL WHEELS.
Units Affected:
34717
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
NOV 24, 1997 |
| Component: |
SERVICE BRAKES, HYDRAULIC:ANTILOCK |
| Model Affected: |
CAPRICE |
| Units Affected: |
56701
Recall Details
|
Recall Date:
NOV 24, 1997
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ANTILOCK BRAKE SYSTEM (ABS) MODULATOR CAN CORRODE AND LEAK FLUID FROM THE FRONT BRAKE CIRCUIT.
Consequence:
BRAKE FLUID LEAKAGE CAN REDUCE BRAKE EFFECTIVENESS AND INCREASE STOPPING DISTANCES.
Remedy:
DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE ABS MODULATOR.
Units Affected:
56701
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
FEB 09, 1993 |
| Component: |
ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS |
| Model Affected: |
CAPRICE |
| Units Affected: |
20000
Recall Details
|
Recall Date:
FEB 09, 1993
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
SYSTEM: ELECTRICAL.VEHICLE DESCRIPTION: SEQ 9C1 POLICE CARS IN CORROSION AREAS OF THE US AND CANADA ONLY. NOTE: VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEWJERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. A ELECTRICAL GROUND-OUT CONDITION MAY EXIST BETWEEN THE 12 VOLT JUNCTION BLOCK AND THE METAL INNER FENDER SKIRT.
Consequence:
THIS CONDITION CAN CAUSE A MELTED JUNCTION BLOCK, SMOKE,AND BURNED UNDERHOOD WIRING RESULTING IN A DISABLED VEHICLE OR A VEHICLE FIRE.THIS CONDITION CAN OCCUR WHILE THE VEHICLE IS IN OPERATION OR WHILE THE VEHICLEIS PARKED AND THE IGNITION IS IN THE "OFF" POSITION.
Remedy:
INSTALL A SHIELDING INSULATOR UNDER THE JUNCTION BLOCK.
Units Affected:
20000
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
OCT 24, 2007 |
| Component: |
EQUIPMENT |
| Model Affected: |
CAPRICE |
| Units Affected: |
121680
Recall Details
|
Recall Date:
OCT 24, 2007
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Consequence:
THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy:
HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
Units Affected:
121680
Notes:
HONEYWELL INTERNATIONAL, INC.
| Recall Date: |
APR 07, 2009 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
CAPRICE |
| Units Affected: |
16270
Recall Details
|
Recall Date:
APR 07, 2009
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Units Affected:
16270
Notes:
SABERSPORT
| Recall Date: |
JAN 19, 1993 |
| Component: |
FUEL SYSTEM, GASOLINE:DELIVERY |
| Model Affected: |
CAPRICE |
| Units Affected: |
1771
Recall Details
|
Recall Date:
JAN 19, 1993
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
THE ENGINE MOUNTED FUEL FEED AND RETURN PIPES MAY FRACTURE DUE TO CONTACT WITH THE ENGINE FRAME DURING OPERATION.
Consequence:
IF THE FUEL PIPE FRACTURES, GASOLINE WILL BE FORCED ATPRESSURE FROM THE FUEL PIPES INTO THE ENGINE COMPARTMENT, RESULTING IN ANUNDERHOOD FIRE IF THE GASOLINE IS EXPOSED TO A SOURCE OF IGNITION.
Remedy:
REPLACE THE FUEL FEED AND RETURN PIPES USING NEW PIPE ASSEMBLIES.
Units Affected:
1771
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
JAN 31, 1996 |
| Component: |
SUSPENSION:REAR |
| Model Affected: |
CAPRICE |
| Units Affected: |
154214
Recall Details
|
Recall Date:
JAN 31, 1996
Model Affected:
1992 CHEVROLET CAPRICE
Summary:
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence:
THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy:
DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
Units Affected:
154214
Notes:
GENERAL MOTORS CORP.