|
Pontiac Sunfire Recalls
| Recall Date: |
MAR 23, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
SUNFIRE |
| Units Affected: |
61944
Recall Details
|
Recall Date:
MAR 23, 2006
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Units Affected:
61944
Notes:
PRO-A MOTORS, INC.
| Recall Date: |
FEB 16, 1995 |
| Component: |
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Model Affected: |
SUNFIRE |
| Units Affected: |
21340
Recall Details
|
Recall Date:
FEB 16, 1995
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence:
THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy:
DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Units Affected:
21340
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
OCT 17, 2008 |
| Component: |
STEERING |
| Model Affected: |
SUNFIRE |
| Units Affected: |
3855
Recall Details
|
Recall Date:
OCT 17, 2008
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Consequence:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Units Affected:
3855
Notes:
DORMAN PRODUCTS, INC.
| Recall Date: |
DEC 17, 1996 |
| Component: |
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS |
| Model Affected: |
SUNFIRE |
| Units Affected: |
270014
Recall Details
|
Recall Date:
DEC 17, 1996
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence:
IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy:
DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Units Affected:
270014
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
JAN 02, 1996 |
| Component: |
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) |
| Model Affected: |
SUNFIRE |
| Units Affected: |
28068
Recall Details
|
Recall Date:
JAN 02, 1996
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
THE INSTRUMENT PANEL CLUSTER TRIM PLATE/BEZEL CAN SAG AND COVER THE LIGHT EMITTING DIODE PORTION (LIGHTED POINTED ABOVE PANEL) OF THE TRANSAXLE SHIFT INDICATOR DISPLAY. THIS DOES NOT COMPLY WITH FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION."
Consequence:
CONSEQUENCE OF NON-COMPLIANCE: THE DRIVER OF THE VEHICLE WOULD NOT BE ABLE TO SEE THE ACTUAL POSITION OF THE TRANSAXLE GEAR SELECTOR RESULTING IN A DRIVER EITHER INADVERTANTLY LEAVING A PARKED OR IDLING VEHICLE IN DRIVE, REVERSE, OR NEUTRAL RATHER THAN PARK, OR SELECTING AN INCORRECT TRANSAXLE SHIFT POSITION WHILE DRIVING THE VEHICLE.
Remedy:
DEALERS ARE TO INSTALL A NEW INSTRUMENT PANEL CLUSTER TRIM PLATE/BEZEL ASSEMBLY WHICH IS NOT SUBJECT TO THIS CONDITION.
Units Affected:
28068
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
MAR 06, 2002 |
| Component: |
ELECTRICAL SYSTEM:IGNITION:SWITCH |
| Model Affected: |
SUNFIRE |
| Units Affected: |
1589948
Recall Details
|
Recall Date:
MAR 06, 2002
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence:
IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy:
DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Units Affected:
1589948
Notes:
GENERAL MOTORS CORP. 02008
| Recall Date: |
JUL 26, 1995 |
| Component: |
STRUCTURE:FRAME AND MEMBERS |
| Model Affected: |
SUNFIRE |
| Units Affected: |
16
Recall Details
|
Recall Date:
JUL 26, 1995
Model Affected:
1995 PONTIAC SUNFIRE
Summary:
SOME WELDS WERE OMITTED FROM THE BODY LOCK PILLAR, OR "B" PILLAR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence:
CONSEQUENCE OF NON-COMPLIANCE: IF A VEHICLE CRASH SHOULD OCCUR, OCCUPANT PROTECTION LEVELS COULD BE REDUCED.
Remedy:
ALL VEHICLES IN THIS RECALL CAMPAIGN HAVE BEEN REPURCHASED AND REPLACED WITH A COMPARABLE VEHICLE.
Units Affected:
16
Notes:
GENERAL MOTORS CORP.
|
|