|
Toyota Tundra Recalls
| Recall Date: |
JUL 20, 2005 |
| Component: |
AIR BAGS:FRONTAL |
| Model Affected: |
TUNDRA |
| Units Affected: |
2527
Recall Details
|
Recall Date:
JUL 20, 2005
Model Affected:
2005 TOYOTA TUNDRA
Summary:
CERTAIN PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND OPTIONAL FABRIC FRONT CAPTAIN'S CHAIRS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THESE VEHICLES WERE BUILT WITH AN INCORRECT FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM INDICATOR LIGHT LENS WHICH WILL NOT DISPLAY THE STATUS OF THE FRONT PASSENGER AIR BAG.
Consequence:
AS A RESULT, THE VEHICLE OCCUPANTS WILL NOT BE MADE AWARE OF WHETHER OR NOT THE AIR BAG IS ACTIVATED AND READY TO PROTECT THE OCCUPANT AS APPROPRIATE.
Remedy:
DEALERS WILL REPLACE THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM INDICATOR LENS. THE RECALL BEGAN AUGUST 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
2527
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 50K
| Recall Date: |
MAR 30, 2005 |
| Component: |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM |
| Model Affected: |
TUNDRA |
| Units Affected: |
5726
Recall Details
|
Recall Date:
MAR 30, 2005
Model Affected:
2005 TOYOTA TUNDRA
Summary:
CERTAIN PICKUP TRUCKS EQUIPPED WITH BOTH VEHICLE STABILITY CONTROL (VSC) AND THE TRD DUAL EXHAUST SYSTEMS. THE TRD DUAL EXHAUST SYSTEM MET ALL CLEARANCE SPECIFICATIONS ON MODELS WITHOUT VSC, HOWEVER THE DRIVER'S SIDE EXHAUST LOCATED IN A POSITION WHERE CONTACT BETWEEN A BRAKE LINE FOUND ONLY ON VEHICLES WITH VSC AND THE TRD EXHAUST PIPE MIGHT OCCUR.
Consequence:
IN THIS CONDITION, THE EXHAUST PIPE FLANGE MAY RUB AGAINST THE RIGHT REAR BRAKE LINE, WHICH COULD CAUSE BRAKE FLUID LEAKAGE. THIS COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL INSPECT AND, IF SO EQUIPPED, WILL REPLACE THE TRD DUAL EXHAUST SYSTEM FREE OF CHARGE. DURING THIS REPLACEMENT, THE DEALER WILL ALSO INSPECT THE SPECIFIC BRAKE LINE TO ASSURE IT HAS NOT BEEN DAMAGED AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON MAY 31, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
5726
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 50E
| Recall Date: |
JUN 02, 2005 |
| Component: |
AIR BAGS:ON-OFF SWITCH ASSEMBLY |
| Model Affected: |
TUNDRA |
| Units Affected: |
156111
Recall Details
|
Recall Date:
JUN 02, 2005
Model Affected:
2005 TOYOTA TUNDRA
Summary:
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD RESTRAINT LOWER ANCHORAGE SYSTEM IN THE FRONT PASSENGER SEAT. THIS SPECIFICATION DOES NOT MEET THE STANDARD REQUIREMENTS.
Consequence:
THIS STANDARD ESTABLISHES REQUIREMENTS FOR CHILD RESTRAINT ANCHORAGE SYSTEMS TO ENSURE THEIR PROPER LOCATION AND STRENGTH FOR THE EFFECTIVE SECURING OF CHILD RESTRAINTS, TO REDUCE THE LIKELIHOOD OF THE ANCHORAGE SYSTEMS' FAILURE, AND TO INCREASE THE LIKELIHOOD THAT CHILD RESTRAINTS ARE PROPERLY SECURED AND THUS MORE FULLY ACHIEVE THEIR POTENTIAL EFFECTIVENESS IN MOTOR VEHICLES.
Remedy:
DEALERS WILL REMOVE THE MANUAL AIR BAG ON-OFF SWITCH, REPLACE THE OWNER'S MANUAL, AND AFFIX A NEW SUN VISOR AIR BAG WARNING LABEL. THE RECALL BEGAN IN EARLY JANUARY 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
156111
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 70A
| Recall Date: |
JAN 19, 2007 |
| Component: |
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Model Affected: |
TUNDRA |
| Units Affected: |
533124
Recall Details
|
Recall Date:
JAN 19, 2007
Model Affected:
2005 TOYOTA TUNDRA
Summary:
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Consequence:
IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.
Remedy:
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
533124
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 70B
| Recall Date: |
MAY 24, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
TUNDRA |
| Units Affected: |
27176
Recall Details
|
Recall Date:
MAY 24, 2006
Model Affected:
2005 TOYOTA TUNDRA
Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Units Affected:
27176
Notes:
CK MOTORSPORT, INC.
|
|