1992 Jeep Wrangler Recalls
S Utility
1992 Jeep Wrangler Recall Record
Recall ID # 02V041000 - PARKING BRAKE:CONVENTIONAL
Recall Date:
FEB 07, 2002
Component:
PARKING BRAKE:CONVENTIONAL
Description
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Consequence
THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSTALL A PARKING BRAKE ASSEMBLY WITH A STRONGER PAWL RETURN SPRING. OWNER NOTIFICATON BEGAN SEPTEMBER 30, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Manufacturer
DAIMLERCHRYSLER CORPORATION B03
Recall ID # 94V106000 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Recall Date:
JUN 09, 1994
Component:
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Description
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Consequence
FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy
REPLACE THE FUEL TANK SENDING UNIT GASKET.
Manufacturer
CHRYSLER CORPORATION
Recall ID # 93V083000 - ELECTRICAL SYSTEM:IGNITION:SWITCH
Recall Date:
MAY 11, 1993
Component:
ELECTRICAL SYSTEM:IGNITION:SWITCH
Description
SALT CORROSION PRODUCTS BETWEEN THE STARTER SOLENOID WIRE AND THE ADJACENT BATTERY FEED IN THE BULKHEAD CONNECTOR MAY SHORT THESE CONNECTIONS, CAUSING THE CIRCUIT TO BYPASS THE IGNITION KEY CONTROL OF THE STARTER MOTOR SOLENOID. THE CAR CAN START WITHOUT THE STARTER SEQUENCE BEING INITIATED BY THE IGNITION KEY IN THE IGNITION LOCK.
Consequence
THE UNINTENDED START OF A VEHICLE WITH A MANUALTRANSMISSION LEFT IN A DRIVE GEAR CAN RESULT IN A RUNAWAY VEHICLE.
Remedy
THE STARTER SOLENOID WIRING WILL BE SEPARATED FROM THE BATTERY FEED WIRE BY RELOCATING IT WITHIN THE BULKHEAD CONNECTOR ON AFFECTED VEHICLES.
Manufacturer
CHRYSLER CORPORATION
Recall ID # 92V148000 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Recall Date:
OCT 14, 1992
Component:
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Description
ON 1987 THROUGH EARLY 1990 MODELS, BOTH FRONT BRAKE HOSES CAN WEAR DUE TO DIRECT CONTACT WITH THE WHEEL OPENING SPLASH SHIELDS. ON THE LATE 1990 THROUGH 1992 MODELS, PERIODIC RUBBING CONTACT OF THE LEFT FRONT BRAKE HOSE CAN OCCUR DUE TO MOVEMENT OF THE SPLASH SHIELD IN CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence
EITHER CONDITION CAN CAUSE LOSS OF FRONT BRAKE SYSTEMFUNCTIONS, RESULTING IN INCREASED STOPPING DISTANCES AND AN INCREASED RISK OFVEHICLE ACCIDENT.
Remedy
THE 1987 TO 1990 MODEL VEHICLES WILL HAVE BOTH SPLASH SHIELDS REPLACED AND BOTH FRONT BRAKE HOSES REPLACED AS NECESSARY. ALL AFFECTED LATE 1990 THROUGH 1992 MODEL YEAR VEHICLES WILL HAVE ADDITIONAL FASTENERS INSTALLED TO FURTHER SECURE THE LEFT SIDE SPLASH SHIELD. ALSO, THE LEFT FRONT BRAKE HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY.
Manufacturer
CHRYSLER CORPORATION
Recall ID # 04E041000 - EQUIPMENT
Recall Date:
JUN 07, 2004
Description
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
Consequence
SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy
BESTOP WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNER NOTIFICATION BEGAN JUNE 16, 2004. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BESTOP CUSTOMER SERVICE DEPARTMENT AT (800) 845-3567.
Manufacturer
BESTOP, INC.
Recall ID # 06E026000 - EXTERIOR LIGHTING
Recall Date:
MAR 23, 2006
Component:
EXTERIOR LIGHTING
Description
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Manufacturer
PRO-A MOTORS, INC.